自動排水器的如何進行工作的？

自動排水器用在自動排除管道低處、油水分離器、氣罐及各種過濾器底部等處的冷凝水?？砂惭b在人工排污水不便的地方，因人工排水常常會遺忘，造成壓縮空氣被冷凝水污染。

The automatic drainer is used to automatically drain the condensed water at the lower part of the pipeline, the oil-water separator, the air tank and the bottom of various filters. It can be installed in the place where it is inconvenient to discharge the sewage manually. Because of the artificial drainage, the compressed air is often polluted by condensed water.

自動排水器是利用空壓系統里的空氣壓，經由一條導管連接，其頂端的泄壓閥能調整微量排氣，讓排水器的壓力低于空壓系統，可將冷凝水、油泥和銹渣推擠遠離空壓系統。

The automatic drainer uses the air pressure in the air pressure system and is connected through a pipe. The pressure relief valve at the top of the automatic drainer can adjust the micro exhaust, so that the pressure of the drainer is lower than that of the air pressure system, and can push the condensate, oil sludge and rust residue away from the air pressure system.

山東自動排水器

Shandong automatic drainer

它有電子的和物理的，電子排水器的原理是電磁閥控制閥門的開和關，可以通過設置上面的開關調節自動排水開啟的時間和周期；物理的排水器就是靠排水器里的浮標的浮力來開啟排水器。排水器里的液面上升，浮標上升，閥門就自動開啟了。

It has electronic and physical. The principle of electronic drainer is that the solenoid valve controls the opening and closing of the valve, and the opening time and cycle of automatic drainage can be adjusted by setting the switch above; the physical drainer is to open the drainer by the buoyancy of the buoy in the drainer. When the liquid level in the drain rises, the buoy rises and the valve opens automatically.

把這些水分與雜質連續擠壓后，輸入積存在自動排水器的下方，再由浮球升高來打開上方的控制器之閥門，再定量自動排放與關閉，這種裝置可有效的保持空壓系統潔凈，而且安裝時可不受高度與距離的限制，可隨意安裝在理想位置，它更不需要使用電源或其他控制導管即可靈活而精準的排放水分與污垢。

After the moisture and impurities are continuously extruded, the input product is stored under the automatic drainer, and then the valve of the upper controller is opened by the floating ball, and then the quantitative automatic discharge and closing can be realized. This device can effectively keep the air pressure system clean, and can be installed in the ideal position without the limitation of height and distance when installing, and it does not need to use power supply or other controls The tube can discharge water and dirt flexibly and accurately. ??

自動排水器的另一特殊設計結構，即氣體、液體、固體三態三層分離結構可使控制器免于浸泡在油污與水分中，這些污水等流體不經過控制器，此控制器的氣體通路有三重的過濾裝置，不會使控制通路阻塞及損壞零件，在使用長久時間后，仍可有效靈活控制而不故障。

Another special design structure of automatic drainer, i.e. gas, liquid and solid three-layer separation structure, can prevent the controller from being immersed in oil and water. These sewage and other fluids do not pass through the controller. The gas path of the controller has a triple filtering device, which will not block the control channel and damage the parts. After a long time of use, it can still be effectively and flexibly controlled Obstacles.